Vararam Tri-Power Manual de usuario descargar pdf

PLEASE READ CAREFULLY AND COMPLETELY

BEFORE BEGINNING THIS INSTALLATION,

you will nd many helpful hints in the instructions.

IF YOU ARE UNCOMFORTABLE WITH ANY ASPECT OF THIS INSTALLATION PLEASE REFER

THIS TO AN EXPERIENCED SERVICE TECHNICIAN.

Tools needed:

1 at head screwdriver

1 10mm wrench or socket

1 small soft towel (its going to get dirty)

1Box knife or cutting tool ex.. Pliers, shears etc..(Avalanche)

Removing the factory intake system.

Remove factory engine cover by lifting up and pull towards the front of the vehicle, you will re-install this later.

Remove the PVC line as shown

Remove the factory air box by unscrewing the hose clamp directly on the box. Pull directly up on the box, it will release with

a pop! Remove the factory air tube by popping it loose from the black plastic grommets located at the middle of the radiator

hose, lossen hose clamp from throttle the body, the hose and intake will lift out.

Mass airow harness-- You will need some slack in the wiring loom for later relocation, to get the added length needed. Pull on

it and nd the plastic grommets on your fender, pop these loose, one or two should be ne, just enough to reach the mouth of

your throttle body.

Step one

1 2 3 4 5 6

Indice de contenidos

Pagina 1 - Step one

PLEASE READ CAREFULLY AND COMPLETELY BEFORE BEGINNING THIS INSTALLATION, you will nd many helpful hints in the instructions.IF YOU ARE UNCOMFORTABLE

Pagina 2 - Tech Note

Removing inner radiator aps (look or feel for these on the left and right of your radiator) Determine which aps you have, hard plastic or soft exib

Pagina 3

Using your cutters remove aps as shown, they are connected by plastic push clips in 3 locationsSUV’s usually have the soft fabric ex Avalanche, Escal

Pagina 4

Install supplied brackets as shown, they are slotted, so simply slide them in place and tighten the 10mm bolt that is under the core support on both s

Pagina 5

Pull Away Towel.Install main hoses as shown in gures. Squeeze the end of the hose on the air box to verify that you are on the edge of the box; this

Pagina 6

Helpful hints and F&Q’s (READ THESE)1. Clean your lter every 2,500-3Kmiles for optimum performance other wise every 6K is ne. (See website fo